< PILOT > Power-Propelled MORStak Drum Racker


Key features

  • Lift, transport and rack a rimmed 55-gallon (210 liter) steel or plastic drum up to 10.5' (3.2 m) high
  • Move drums on and off racks, pallets, trucks, etc.
  • Lift an upright drum and place in horizontal position
  • Position drums in rack with virtually zero clearance in between
  • Has internally-mounted 24V battery powered drum lift and tilt
  • Familiar controls for propulsion and steering, and handle includes Raise and Lower buttons
  • 800 Lb. (363 kg) Full Drum Capacity

Request Quote Model Chart


< PILOT > Model # 910 Power-Propelled MORStakTM walkie stacker allows you to rack a 55-gallon (210 liter) steel or plastic drum horizontally up to 10.5 feet (3.2 m) high. This safety conscious, self-propelled MORStakTM Drum Racker allows you to move drums on and off racks, pallets, trucks, etc. Lift an upright drum and place in horizontal position. Rack rimmed 55-gallon steel or plastic drums side by side with virtually zero clearance between them. Handle your drum with a drum faucet in place, allowing your drum rack to serve as a dispensing station. Capacity is 800 Lb. (363 kg). The control handle features raise and lower buttons, speed control, a horn, and "belly-button" reversing switch. The panel on which the Lift and Tilt Control Levers are located also features an on/off switch and the battery disconnect. Control the travel speed with ergonomic twist grip or thumb control. Maximum travel speed is 3.0 mph (4.8 km/hr) or 4.4 ft/sec (1.3 m/sec) with 800 Lb. (363 kg) drum. Maneuver in narrow aisles with a turn radius of just 58” (147 cm) on smooth rubber rear drive wheels, and polyurethane front wheels. Traveling on a slope: The Pilot series is rated for operation up to a 5% grade when traveling with the carriage and attachment down below the high speed cutoff height. Adjust straddle I.D. from 38” to 50” (96.5 to 127 cm), adjustable in 4” increments to work with various size pallets. Moving steering control handle to top and bottom 15° of handle arc actuates brake proportional to handle movement, allowing operator complete control of braking from “feathering” for accurate payload positioning through full emergency stop. When released, the handle returns to upright position and applies the brake. Built-in safety systems include a proven “belly-button” switch, which helps prevent an operator being pinned between the < PILOT > and any other object. Upon body contact, the switch activates low speed in the opposite direction. “Dead-man” braking occurs when spring loaded control handle is released, turning off electrical power and applying the brakes. The internally mounted 24V battery has a built-in “smart” charger to provide amount of charge necessary. Simply plug into a standard 110V AC outlet with the included cord. The batteries can be fully charged from empty in about 8 hours. NOTE: Morse does NOT make or sell drum racks. We manufacture the Drum Racker.

Model Chart

Product Description
910 < PILOT > Power-Propelled MORStak Drum Racker. Lift and rack RIMMED 55 gallon (210L) steel or plastic drum horizontally up to 10.5'(3.2m) high.

California Proposition 65 Information


...
WARNING: This product can expose you to chemicals including barium sulfate, cobalt, titanium dioxide, and 2-methylimidazole, which are known to the State of California to cause cancer, and bisphenol-A, which is known to the State of California to cause birth defects or other reproductive harm.

For more information go to www.P65Warnings.ca.gov